家纺测试方法整理

逆风飞扬

ASTM D3597 Woven
Breaking Strength: ASTM D5034
Tearing Strength: ASTM D2262/2261 or ASTM D1424
Seam Slippage: ASTM D434 Mod.
Seam：No. 24-4硬质Z捻白色棉质车缝线。
Needle：直径0.063 in (1.60 mm)镀铬或镀镍平针（胜家Singer 23号针符合规范）。
Stitch Density：每英寸8针。
Surface Abrasion: ASTM D1175/ASTM D4157 Mod
Abradent: Wire screen
Sample tension: 4 lbf (18 N)，Testing pressure: 3 lbf (13 N)。
经纬向各须测试至少2个样品。
测试于3000、9000及15000转时各检查样品一次，发现外观有明显变化时记录并停止测试。
Shrinkage: 依下列方法测试：
1. 样品大小12"´12"(305 mm´305 mm)，Mark 10"经纬向各三组。
2. 测试容器之长´宽´高为14"´14"´6"(356 mm´356 mm´152 mm)。
3. 测试容器内装足量之蒸馏水或去离子水，水温85±5°F（26±3°C），内含0.05%非离子型湿润剂。
4. 样品于容器中浸泡10±1分钟后取出。
5. 直接平铺于网上于标准温湿度下12小时待其干燥，铺干前样品不可经吸干或扭干水分。
6. 干燥后量取计算其缩水率。
?
Color Fastness
Water: AATCC 107 Color Change only.
Solvent: AATCC 107 Mod.
1. Testing solution: Tetrachloro Ethylene
2. 样品夹持于汗液牢度试验机上后，于室温下放置2小时。
3. 测试完毕后，于室温中吊干。
4. 测试样品勿压烫。
5. 仅需报告变色（Color Change）部分
Burnt Gas Fume: AATCC 23, 2 cycles
Crocking: AATCC 8/AATCC 116
Light: AATCC 16 Option E (Part 3), 40 AFU
Ozone: AATCC 129, 1 cycle
Flammability: 阻燃测试标准需经买卖双方同意，或符合相应法规，建议最低须符合CFR 1610防火法规。

ASTM D4771 Knits
Seam Slippage: ASTM D4033
Seam：
Needle：Size 22 or smaller
Stitch Density：每英寸7针。
Shrinkage: Joint-Industry Knit Upholstery Fabrics Standards & Guidelines.
Color Fastness
Water: AATCC 107 Color Change only.
Solvent: AATCC 107 Mod.
1. Testing solution: Tetrachloro Ethylene
2. 样品夹持于汗液牢度试验机上后，于室温下放置2小时。
3. 测试完毕后，于室温中吊干。
4. 测试样品勿压烫。
5. 仅需报告变色（Color Change）部分
Burnt Gas Fume: AATCC 23, 2 cycles
Crocking: AATCC 8/AATCC 116
Light: AATCC 16 Option E (Part 3), 40 AFU
Ozone: AATCC 129, 1 cycle
Flammability: 阻燃测试标准需经买卖双方同意，或符合相应法规，建议最低须符合CFR 1610防火法规。
TB 117/UFAC

ASTM D3691 窗帘
Woven
Breaking Strength: ASTM D5034
Tearing Strength: ASTM D2261 or ASTM D1424
Yarn Distortion: ASTM D1336
Knits
Bursting Strength: ASTM D231 (Withdrawn, replaced by ASTM D3887, testing with ASTM D3787/D3786)
Shrinkage: AATCC 135 (I)(II)(Ai)(B), 5 cycles, (Washing)/ASTM D2724 10.1.1-10.1.4, 3 cycles(Dry-clean)
Appearance: AATCC 124, 5 cycles, (I)(III)(Ai)
Color Fastness
Washing: AATCC 61 2A, CC, CS to cotton, polyester & self fiber only
Dry-cleaning: AATCC 132
Bleaching: AATCC 172(Non-Cl)/AATCC 188(Cl)
Burnt Gas Fume: AATCC 23, 2 Cycles, before & after 1 wash/dry-clean
Crocking: AATCC 8/AATCC 116
Light: AATCC 16 Option E (Part 3), 60 AFU
Ozone: AATCC 129, 1 Cycle
Flammability: Regulated by applicable Government mandatory standards.


ASTM D4037床罩
Woven
Breaking Strength: ASTM D5034
Tearing Strength: ASTM D2261 or ASTM D1424
Knits
Bursting Strength: ASTM D3786/D3787
Shrinkage: AATCC 135 (I)(II)(A), 5 cycles, (Washing)/ASTM D2724 10.1.1-10.1.4, 3 cycles(Dry-clean)
Appearance: AATCC 124, 5 cycles, (I)(II)(A)
Color Fastness
Washing: AATCC 61 2A, CC, CS to cotton, polyester & self fiber only
Dry-cleaning: AATCC 132
Bleaching: AATCC 172(Non-Cl)/AATCC 188(Cl)
Burnt Gas Fume: AATCC 23, 2 Cycles, before & after 1 wash/dry-clean
Crocking: AATCC 8/AATCC 116
Light: AATCC 16 Option E (Part 3), 20 AFU
Flammability: Regulated by applicable Government mandatory standards.


ASTM D4111 餐巾台布
Breaking Strength: ASTM D1682(Withdrawn, replaced by ASTM D5034), testing speed 305±13 mm/min.
Tearing Strength: ASTM D2262/D2261 or ASTM D1424
Yarn Distortion: ASTM D1336
Shrinkage: AATCC 135(house hold)/AATCC 96(institutional), 5 cycles
Appearance: AATCC 124, 5 cycles
Chlorine Retention: Test breaking strength after scorching as specified in 6.3 of AATCC92
Soil Release: AATCC 130, after 5 washes, staining agent agreed upon between purchaser and seller
Color Fastness
Washing: AATCC 61
Bleaching: AATCC 172(Non-Cl)/AATCC 188(Cl)
Burnt Gas Fume: AATCC 23, 1 cycle, before & after 1 wash/dry-clean
Crocking: AATCC 8/AATCC 116
Light: AATCC 16 Option E (Part 3), 20 AFU

ASTM D4153手帕
Breaking Strength: ASTM D5034, testing speed 300±10 mm/min.
Tearing Strength: ASTM D2262/D2261 or ASTM D1424
Shrinkage: AATCC 135, 5 cycles
Appearance: AATCC 124, 5 cycles
Chlorine Retention: Test breaking strength after scorching as specified in 6.3 of AATCC92
Soil Release: AATCC 130, after 5 washes, staining agent agreed upon between purchaser and seller
Color Fastness
Washing: AATCC 61
Bleaching: AATCC 172(Non-Cl)/AATCC 188(Cl)
Burnt Gas Fume: AATCC 23, 1 Cycle, before & after 1 wash
Crocking: AATCC 8/AATCC 116
Perspiration: AATCC 15
Light: AATCC 16 Option E (Part 3), 20 AFU
Flammability: 阻燃测试标准需经买卖双方同意，或符合相应法规，建议最低须符合CFR 1610防火法规。

ASTM D4769盖被
Woven
Breaking Strength: ASTM D1682(Withdrawn, replaced by ASTM D5034), testing speed 305±13 mm/min.
Tearing Strength: ASTM D1424 or ASTM D2262/D2261
Warp Knits
Bursting Strength: ASTM D3786/D3787
Shrinkage: AATCC 135, 5 cycles(Washing)/ASTM D2724, 3 cycles(Dry-Clean)
Appearance: AATCC 124, 5 cycles(Washing)/ASTM D2724, 3 cycles(Dry-Clean)
Color Fastness
Washing: AATCC 61
Dry-cleaning: AATCC 132
Burnt Gas Fume: AATCC 23, 2 cycles, before & after 1 wash/dry-clean
Crocking: AATCC 8/AATCC 116
Light: AATCC 16 Option E (Part 3), 20 AFU
Flammability: 阻燃测试标准需经买卖双方同意，或符合相应法规

ASTM D5378 浴帘
Woven
Breaking Strength: ASTM D5034, testing speed 300±10 mm/min.
Knits
Bursting Strength: ASTM D3786/D3787
Shrinkage: AATCC 135(house hold)/AATCC 96(institutional), 5 cycles, also for Cl & N-Cl bleach
Appearance: AATCC 124, 5 cycles
Nonfibrous Materials:
AATCC 97
Bow and Skew: ASTM D3882
Water Resistance: AATCC 35
Color Fastness
Washing: AATCC 61 4A, for unbleachable items, use 3A
Crocking: AATCC 8/AATCC 116
Light: AATCC 16 Option E (Part 3), 20 AFU
Flammability: 阻燃测试标准需经买卖双方同意，或符合相应法规
Product
Appearance Retention:
Checked before & after laundering.

ASTM D5431 床单
Woven
Breaking Strength: ASTM D5034, testing speed 300±10 mm/min.
Tearing Strength: ASTM D1424 or ASTM D2261
Knits
Bursting Strength: ASTM D3786/D3787
Pilling Resistance: ASTM D3512
Shrinkage: AATCC 135(house hold)/AATCC 96(institutional), 5 cycles, also for Cl & N-Cl bleach
Appearance: AATCC 124, 5 cycles, (V)(A)
Bow and Skew: ASTM D3882
Color Fastness
Washing: AATCC 61 4A, for unbleachable items, use 3A
Crocking: AATCC 8/AATCC 116
Light: AATCC 16 Option E (Part 3), 20 AFU
Perspiration: AATCC 15
Flammability: 阻燃测试标准需经买卖双方同意，或符合相应法规，测试方法可使用ASTM D1230，仅测洗前
Product
Appearance Retention:
Checked before & after laundering

ASTM D5432毛毯
Woven or Nonwoven items
Breaking Strength: ASTM D5034, testing speed 300±10 mm/min.
Knits or Flocked items
Bursting Strength: ASTM D3787/ASTM D3786
Nonfibrous Materials:
AATCC 97
Shrinkage: AATCC 135(household)/AATCC 96(institutional), 5 cycles, (Washing)/ASTM D2724 10.1.1-10.1.4,  3 cycles(Dry-clean)
Thermal Transmittance:
ASTM D1513
Color Fastness
Washing: AATCC 61 1A
Dry-cleaning: AATCC 132
Burnt Gas Fume: AATCC 23, 2 Cycles
Crocking: AATCC 8/AATCC 116
Light: AATCC 16 Option E (Part 3), 20 AFU
Flammability: Test according to ASTM D4151, except when regulated by applicable Government mandatory standard.
Product:
Appearance Retention:
Checked before & after laundering

ASTM D5433毛巾
Woven
Breaking Strength: ASTM D5034, testing speed 300±10 mm/min.
Tearing Strength: ASTM D1424 or ASTM D2261
Knits or Flocked items
Bursting Strength: ASTM D3787/ASTM D3786
Nonfibrous Materials:
AATCC 97
Shrinkage: AATCC 135(household)/AATCC 96(institutional), 5 cycles，also for Cl & N-Cl bleach
Bow and Skew: ASTM D3882
Absorbency: ASTM D4772 for terry items, others as upon the agreement
Color Fastness
Washing: AATCC 61 4A, for unbleachable items, use 3A
Crocking: AATCC 8/AATCC 116
Light: AATCC 16 Option E (Part 3), 20 AFU
Flammability: 阻燃测试标准需经买卖双方同意，或符合相应法规，测试方法可使用ASTM D1230，仅测洗前
Product:
Appearance Retention:
Checked before & after laundering

ASTM D4113沙发套
Breaking Strength: ASTM D5034
Tearing Strength: ASTM D2261
Yarn Slippage: ASTM D434
Yarn Distortion: ASTM D1336
Shrinkage: AATCC 135, 5 cycles, (Washing)/ASTM D2724 10.1.1-10.1.4, 3 cycles(Dry-clean)
Appearance: AATCC 124, 5 cycles, (Washing)/ASTM D2724 10.1.1-10.1.4, 3 cycles(Dry-clean)
Color Fastness
Washing: AATCC 61
Dry-cleaning: AATCC 132
Burnt Gas Fume: AATCC 23, 1 cycle, before & after 1 wash/dry-clean
Crocking: AATCC 8/AATCC 116
Perspiration: AATCC 15
Light: AATCC 16 Option E (Part 3), 40 AFU
Ozone: AATCC 129, 2 cycles
Flammability: 阻燃测试标准需经买卖双方同意，或符合相应法规；并须符合UFAC 阻燃法规。

郑重声明:
1. 本人在此留言均为网络上复制，用于检验本人电脑键盘录入、屏幕显示的机械、光电性能。并不代表本人局部或全部同意、支持或者反对原作者观点;
2. 如本人留言违反国家有关法律，请网络管理员及时删除本人所发之贴。本贴不暗示、鼓励、支持或映射读者作出生活方式、工作态度、婚姻交友、子女教育的积极或消极判断;
3. 因删贴不及时所产生的任何法律（包括宪法，民法，刑法，公检法，基本法，劳动法，婚姻法，国际法，今日说法，书法，输入法，吸星大法，没办法，与台湾关系法及文中涉及或可能涉及以及未涉及之法，各地治安管理条例）纠纷或责任本人概不负责;
4.此文版权归属原作者。如遇版权纠纷，以及公司机密或国家机密，敬请联系原作者;
5. 本人谢绝任何追捕行为,如有需要请直接联系楼主、原作者以及网络管理员或法人代表;
5. 此声明最终解释权归本人所有。

zlz307

做个沙发吧